Front to rear condensate path open: adding that if it's not open and your AC is pretty level, it will run out the front and your carpet will get wet. BTDT
Didn't know it was clogged. Not clogged any more.
Condensate is picked by the slinger ring on the condenser fan and blown across the coils. The heat of evaporation of water is enormous and greatly aids in the efficiency of window AC units. Cooling the high pressure liquid reduces the head pressure on the compressor since pressure and temp are directly related. It takes watts of power to compress freon at high head pressures. The lower you can get it the lower the wattage required to compress a given volume of refrigerant.
What you pay for this efficiency is that the water that is slung on the condenser coil is wet and as the condenser fan blows air across the coil, any dust in the air mixes with the water and makes goo, like in the picture.
So, every year or so, depending on your situation, the unit needs to be removed and washed out as some have mentioned. If you don't clean the coils you reduce the air across the condenser which means you don't cool the high pressure freon as you should and the overall system heat goes up driving your light bill up and your cooling ability down. It's no big deal for an entrance level fixer upper. Just be careful with the coils and get the short screws back where they were. Short screws in the right places don't punch holes in refrigerant lines.
To clean the condenser effectively you need to get at the inside of the coil meaning you need to remove some sheet metal. Be extremely careful in cleaning the fins as they are very fragile and the spacings as you had when the unit was new need to be maintained (no smashed fins) to allow for proper air circulation and efficiency. Also take care to maintain the sealed system intact so that you don't open any seams and cause your freon to leak out. No freon, no cooling.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Gatherin of the Orange - by Rick Nikolich. In July of 1998 I was talking to fellow Allis Chalmers collector Mike Schilling about the annual "Gathering of The Orange" AC show coming up in August of 1999. He got this wild idea that we should get a convoy of AC tractors and drive them from Charlotte, Michigan 105 miles to LaGrange, Indiana.
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
