Posted by toopoor2fix on February 07, 2020 at 15:18:26 from (184.170.177.165):
I have a JD 4240 that I had to replace the right hand windshield wiper motor with a new motor that replaces the OEM motor that is no longer made. The old motor had only 3 leads (low speed, high speed, and ground). The new "universal jd" motor has 5 leads which appear to be low speed, high speed, park, washer mode, and ground.
Connected new motor to the low, high and ground leads from the tractor. Left the other two leads on the motor alone.
My problem is that if I turn the switch on, nothing happens, however, if I turn the key off, turn the switch on, then turn the key on, the wiper will operate normally.
I can also have the key and switch on and disconnect the lead at the wiper motor and motor will start and operate normally.
I am of the opinion that the circuit breaker on the switch is tripping when the switch is turned on.
It seems to me that if the motor start load is too much for the circuit breaker, it should trip all the time, not just from turning the wiper switch on.
There were no instructions with the new wiper motor, so I am hesitant to replace the switch, without knowing whether I needed to have wired the motor differently from what the old motor was.
I am the third owner of this tractor and it is obvious the wiring under the dash and under the cab are far from original.
What I am confused about is why wiper motor will operate normally if the switch is turned on before power is applied to the motor, but not if the wiper switch is used to supply the power?
Upload one or more videos to your post. Photo and video filesizes should be less than 8MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Gatherin of the Orange - by Rick Nikolich. In July of 1998 I was talking to fellow Allis Chalmers collector Mike Schilling about the annual "Gathering of The Orange" AC show coming up in August of 1999. He got this wild idea that we should get a convoy of AC tractors and drive them from Charlotte, Michigan 105 miles to LaGrange, Indiana.
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
