|
Tractor Talk Discussion Board |
CUB points
[ Expand ] [ View Replies ] [ Add a Reply ] [ Return to Forum ]
Posted by Wess C on February 04, 2007 at 11:10:42 from (68.228.137.249):
On a 1948 CUB with original 6 volt positive ground I cleaned and set the point to .20 and disconnected the condenser , separated the wire from the points to the coil and installed a TIP3055 npn transistor (276-2020) and one diode and guess what....instead of 4.6 amps at the points now its only 70 ma (.07)amps the points go to the base , emitter to the coil , and the collector to the positive ground ,diode is 6 amp 50 volt (276-1661) between the collector and the emitter band towards the collector . The fire is a lot hotter ,so I Doubled the spark gap from .23 to .45 and the points are still at .07 amps .There is no spark or arc visible at the points , the only wear would be at the wiper or spring in about 15 years . I just have it hanging there on a pease of aluminum now but it will bolt down with a small heat sink(276-1368)in place of the condenser under the cap. not bad for under $6.00
A LED could be added between the emitter and collector with a 100 ohm resister that would light to indicate the open points which is when the spark occurs . This may be handy for adjusting timing however it is not needed and if you don't move the distributor the timing shouldn't change if the point gap is correct.
This is not true breakerless electronic ignition , more like a electronic switch that takes the high current off the points contacts , if a good lube is used un the wiper, and just a touch where the spring attaches who knows how long they would last.
Numbers in parenthesis are Radio Shack catalog numbers.
Replies:
Home
| Forums
Today's Featured Article -
Engine Valves - Some Helpful Information - by Staff. Intake - On the intake stroke the piston moves doward, sucking in carburized fuel through the open intake valve. Exhaust valve is closed. Compression - With both the intake and exhaust valves closed, the pistons upward stroke compresses or squeezes the fuel into the combustion chamber. Firing - Ignited by the spark, the compressed fuel explodes and forces the piston downward on its power stroke. Intake and exhaust valves are closed. Exhaust valves and seats are exp
... [Read Article]
Latest Ad:
18-32 Case Cross Motor
[More Ads]
Copyright © 1997-2025 Yesterday's Tractor Co.
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V. Yesterday's Tractors - Antique Tractor HeadquartersWebsite Accessibility Policy |
|
