Quote: "The converter on the logic board that converts from 110 to down to 24 volts is what keeps blowing."
You sound capable so you may be able to consider this point: Is the voltage 'converter' an iron-chunk transformer or a zener diode?
If transformer, look for a wiring fault in the circuit feeding the opener---bad ground, bad neutral. Unlikely but possible is bad incoming voltage from grid--bad breaker, bad bus bar connection in panel. I had something similar and turned out the neutral was nonexistent and I had been running off the earth ground to complete the circuit. Oops.
If 'solid state' "converter" look for poor heat sinking. Look for chunk of aluminum under the device. May not be properly heat sinked or need conductive heat sink grease-like material. In short, you could be experiencing overheat failures.
Do failures coincide with summer high temps in garage? Might experiment by placing small 'trucker fan' near opener and seeing if makes a difference over time.
Do failures seem more or less evident when using radio control compared to wall button? Is wall button hard-wired or also radio type?
Call up maker and be persistent until you get to talk with one of their engineering staff instead of TechRep reading from manuscript. Squeaky wheel and all that. Could be design flaw. Keep asking questions. Ask for replacements of entire unit direct from factory.
Please post back your experiences so we may all learn.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - George's Fordson Major - by Anthony West (UK). This is a bit of a technical info to add on to the article about George's Major in the "A Towny Goes Plowing" article. George bought his Major from a an implement sale about 18 years ago for £200.00. There is no known history regarding its origins or what service it had done, but the following work was undertaken by Harold alone to bring it up to show standard. From the engine number, it was found that the major was produced late 19
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.