Posted by Bob on September 18, 2019 at 08:43:03 from (64.255.159.199):
In Reply to: Extremely stumped... posted by john achmann on September 18, 2019 at 05:31:55:
Quoting Removed, click Modern View to see
If this is for REAL, and the engine dies when the electric clutch is energized, even by a spare battery, it would have to be that the magnetic field from the clutch coil is somehow stopping the electronic ignition from triggering.
Hey, let's confirm that by using a spark tester to verify that spark actually fails! (Also, does this have a electromagnetic fuel shutoff solenoid on the carb that may somehow affected?)
One other though, I think theses engines have ball bearings on the crankshaft, but is it possible there's crankshaft endplay that's affected by the clutch being energized that somehow messes up triggering of the ignition?
That being said, I have read MANY posts on the 'net where a Predator has been installed in a DEERE garden tractor, seems to be a VERY popular repower, and from those reports, they work well.
So what's going on, perhaps ignition system is not quite right/marginal and quits sparking to easily from an external magnetic influence?
I would check "air gap" between flywheel magnets and coil, perhaps a little less or a little more might make a difference?
As I understand you, you have tried powering the clutch coil by a totally separate spare battery.
If that is the case, and you are connecting direct to the clutch coil without ANY tractor wiring involved, just for giggles try reversing the polarity of the power to the clutch coil, battery (-) to the clutch coil lead and battery (+) to the chassis.
This will make the clutch "pull in" but produce a magnetic field of the opposite polarity. Does that affect the engine "dying"?
Upload one or more videos to your post. Photo and video filesizes should be less than 8MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Usin Your Implements: Bucket Loader - by Curtis Von Fange. Introduction: Dad was raised during the depression years of the thirties. As a kid he worked part time on a farm in Kansas doing many of the manual chores. Some of the more successful farmers of that day had a new time saving device called a tractor. It increased the farm productivity and, in general, made life easier because more work could be done with this 'mechanical beast'. My dad dreamed that some day he would have his own tractor with every implement he could get. When he rea
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
