Posted by CapayMiller on July 20, 2020 at 18:11:43 from (38.102.44.1):
Hello again all,
The patient: 4010 w. Delco 24v starter, 2 x 12v batteries + Delco alternator, using a Delco-style series/parallel relay. Had been starting fine until I had the bright idea to replace harness. Then starter barely turned- apparently receiving 12v only. Everything checked out, wired to spec, batt's good, etc. Start problem apparently resolved by running small (10ga) jumper from Bat B + to starter ground terminal. No idea why this worked- but P.O. had a pencil sketch illustrating setup so I followed it. But then, after a week working fine, it stopped starting again. Relay energizes fine, but fuse on + jumper fries instantly when batteries connected.
Suspicion went to starter solenoid. Sure enough, on disassembly solenoid contact plate had clearly welded to contacts at some point, so not releasing. Ordered new solenoid & replaced. Fuse still blows, starter doesn't spin. VOM shows: 12v at batteries 24v at series/parallel relay when starter key turned. Relay energizes as it should 24v at starter solenoid (trigger posts) when key turned 24v at starter battery terminals when key turned
Still, starter either doesn't spin, or barely spins. Was spinning fine last week.
Upload one or more videos to your post. Photo and video filesizes should be less than 5MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - An AC Model M Crawler - by Anthony West. Neil Atkins is a man in his late thirties, a mild and patient character who talks fondly of his farming heritage. He farms around a hundred and fifty acres of arable land, in a village called Southam, located just outside Leamington Spa in Warwickshire. The soil is a rich dark brown and is well looked after. unlike some areas in the midlands it is also fairly flat, broken only by hedgerows and the occasional valley and brook. A copse of wildbreaking silver birch and oak trees surround the top si
... [Read Article]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
