Posted by John_PA on July 06, 2012 at 20:51:08 from (71.182.170.179):
I have a 1997 IH4700 with a DT466 and an Allison AT500 automatic transmission. (wish it were a spicer 7, personally, but I got a good deal on it.)
Here's a refreshing picture of it, on this 100 degree day...
So, taking a 120 bushel load(should be nothing for a dump that can legally carry 13,500 lbs of payload) to the elevator today, it started playing tricks. Now, I know it is hot outside, but, it shouldn't do this. When going uphill on the highway at 55 mph, it started to blow blue smoke pretty heavily out the exhaust pipe. Then, within a few minutes, the tempurature gauge hit 230 and all the warning lights came on for running hot. It is full of coolant. It has 107,000 original miles on it. The one thing it does have is a new muffler that was put on it by a shop in December. I'm wondering if maybe the muffler is restricting teh exhaust flow too much and causing the turbo to get too hot, which is allowing teh seals to leak. Once I go below 55 mph for a distance(say 45 mph) it will quit doing this. I don't have a pyrometer on the exhaust. I'm guessing that it will say I'm running really hot.
Does anyone have any experience with one of these engines in a truck? I fooled with them in tractors, but never in a truck. The transmission really makes that thing rev high almost all the time. running 65 mph it is at 2700 rpm nearly. Coming back, unloaded, it was running cool and no smoke, but I was careful not to go a click above 55 and keep my foot out of the gas tank going up any hills. There is one 7% grade I climb empty that is about 2 miles long. I went up that hill at 40-45 mph empty and it just started to heat up near the top, but, nothing serious.
What would be the first thing to check if I were to start checking things. Any bus mechanics here? I hear the school buses run this combo a lot. I've seen a few single axle fifth wheel trucks for sale with this combo, advertised with a 24 foot grain trailer. After fooling with just 200 bushel at a time, I don't know if I would want to carry 400 bushel with the same drivetrain.
Thanks in advance for any and all suggestions and advice. I really appreciate it.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - What Oil Should I Use? - by Francis Robinson. I keep seein this question pop up over and over again in discussion groups all over the web. As with many things there are often several right answers and a few wrong ones. Some purist I'm sure will disagree to no end with what I will tell you but most of us out here in the real world don't really care do we ? Some of them only bring their noses down out of the air long enough to look down them anyway. If you are like me you are only doing this old tractor stuff because you enjoy it. You
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.